[Biturbos4] Turbos Reliability & Replacement Cost (was: 2000 S4 Running Hot)

j y jimnetpa at yahoo.com
Wed Aug 31 01:29:59 EDT 2005


David Cahill <djcahill at gmail.com> wrote:Normally, I just lurk on this list, but I couldn't resist this topic.

Just to throw some salt in the wounds, I'd like to point out that the 
original turbo on my '92 S4 is still producing 1.3 bar after 307,000 miles. 
That is all.


P.S. - Stock K03s are fine on my 01.5 S4 after 90k miles. As mentioned many 
times before, proper warm-up and cool down are crucial. It helps to toss in 
a little luck. DocSlow on the AW forum had 180k miles on his K03s, I 

On 8/30/05, docwyte at comcast.net wrote:
> The turbos in my S4 Avant blew at 48k miles, on my friends All Road at 45k 
> miles. I think getting 120-150k miles out of a set of K03's just isn't going 
> to happen. On an Ur-S4 or my 951 maybe.
> I had to replace the clutch in my A4 1.8T at 75k miles, but that was due 
> to the fact I was running over 100 hp and 150ft lbs of torque more than the 
> factory specs.
> My stock clutch still holds my current 340hp/400ft lbs of torque fine, but 
> I'd imagine if I put in K04's I'd need to upgrade the clutch as well.
> >From the dyno graphs I've seen and talks I've had with my friend, the 
> K04's spool no slower than the K03's and make more hp and torque all the way 
> across the board over K03's...
> -------------- Original message --------------
> > Wow did we kick up a storm. I get back from Boston to 60 messages :-)
> >
> > Quincy,
> >
> > 1.) I'd assume that on average well maintained turbos go 120-150k
> > miles, not 55. That's a fluke.
> > 2.) I have never replaced an audi clutch. My last two cars went > 200k
> > before I sold them.
> > 3.) ergo, you are being way too conservative/paranoid.
> >
> > As to your deeper question re 03 vs 04 turbos: spool up time is the
> > only answer. but its obviously a trade off you make.
> >
> >
> _______________________________________________
> Biturbos4 mailing list
> Biturbos4 at www.audifans.com
> http://www.audifans.com/mailman/listinfo/biturbos4

*** new address ***
631-B Browns Trace Rd
Jericho, VT 05465
cell: 802-431-3355
home: 802-764-5845
Biturbos4 mailing list
Biturbos4 at www.audifans.com

 Start your day with Yahoo! - make it your home page 

More information about the Biturbos4 mailing list