[Vwdiesel] cold start shaft reseal in car Re: pump still leaks
dieselwesty at yahoo.com
Thu Sep 17 09:09:45 PDT 2009
The pump that was on my 92 Jetta Eco was a late 80's TD pump with a bad input shaft bushing.
It had this type of cold start electrical advance, but it was not hooked up.
I notice my current 1.6TD pump runs at the perfect idle speed when cold, but when the pump heats up, my idle drops a bit low and it AC is on, it is really stuggling. I am guessing this electrical component tied into the AC Compressor turning on and would bump up the advance to get you a little better idle when the motor was under strain? But this would only be needed at idle, not when you are going down the road?
Bryan Belman, Pt. Pleasant, NJ
04 Jetta Wagon TDI PD, 100hp, 5sp -- running :)
92 Jetta 1.6 Eco-Turbo Diesel -- running :)
82 Diesel Westy 1.9NA -- running :}
70 Type 1 stock Beetle -- Not running :(
From: brian gochnauer <brian at gochnauer.net>
To: vwdiesel at vwfans.com
Sent: Thursday, September 17, 2009 11:04:56 AM
Subject: Re: [Vwdiesel] cold start shaft reseal in car Re: pump still leaks
From the pics I've seen the 'electrical component on the front' is the
electric version of a lever that would be the backside. When the there's an
electric solenoid on the front the lever port on the back is blocked off.
On 9/17/09, LBaird119 at aol.com <LBaird119 at aol.com> wrote:
> In a message dated 9/16/2009 7:22:46 PM Pacific Daylight Time,
> decker at toledotel.com writes:
> > The cold start lever is made to work on either side of
> > the pump. Why we have to have it on the back side where it is a chore to
> > get
> > to I don't know.
> I saw a pic once where there was an electrical component on the
> front side where we just have a plate. I don't recall if there was
> also the cable or not. I seem to recall it being a to retard it for
> certain conditions. It wasn't really clear just what it did. May
> have been an additional advance for low load conditions since
> there's something that does something like that, on some models
> of VE pump.
> Vwdiesel mailing list
> Vwdiesel at vwfans.com
Vwdiesel mailing list
Vwdiesel at vwfans.com
More information about the Vwdiesel